How can I make my E-Z-GO golf cart faster?

Increasing the speed of your EZ Go golf cart can be done by reprograming your speed control at the dealer, upgrading your batteries, motor, or replacing your speed control. Upgrading these can increase your typical speed from 12 MPH to 19.5 mph or above depending on your modifications.

How do you remove the speed limiter on a electric golf cart?

Basically, an electric speed governor can be controlled by a tiny metal rod that's located by the clutch of your golf cart. First things first: The electric speed governor is connected to a cable. You can adjust your speed by rotating the nut in a counterclockwise rotation.

How can I make my EZ Go golf cart 36 volt faster?

How to Make a 36 Volt Golf Cart Faster

1. Remove any unnecessary additions, racks or parts on your golf cart. ...
2. Power-wash your cart. ...
3. Check the shaft under the ignition pedal. ...
4. Put larger tires on the cart. ...
5. Replace any old or worn-out parts that are causing the cart to move slower than it should.

How do you adjust the governor on a EZ Go TXT golf cart?

How to Adjust the Governor on a Gas E-Z-Go Golf Cart

1. Locate the governor arm mounted on top of the rear axle case underneath the cart. ...
2. Loosen the adjusting locknut on the end of the governor spring. ...
3. Retighten the adjusting locknut.

How do you take the governor off a golf cart?

General Instructions

1. Detach the cable from the carburetor. The cable is about the width of a straw. ...
2. Follow the disconnected cable up to the governor. ...
3. Disconnect the gas pedal cable from the governor and reroute it to the carburetor. ...
4. Using your wrench, remove the bolt on the gas pedal shaft.

Why is my gas golf cart slow?

Low Battery

Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.

How do I adjust my EZ GO carburetor?

2 Cycle engine: The adjustment screw is on the side of the carburetor and is parallel to the ground. You can identify it by the lock nut at the base of the screw. Loosen this and turn the screw all the way into a soft seat, then back it out one and a half (1-1/2) turns.

How can I make my EZ Go TXT gas faster?

One way to increase the speed of EZ Go golf carts is to incorporate an octane booster when you fill the tank. The cart will have more pick-up, and it could gain as much as 5 mph. A different approach is to take out the throttle linkage governor on the carburetor.

How fast is a EZ Go gas golf cart?

The fastest gasoline Club Car only goes 19 mph. And the fastest electric EZGO is the 2Five that goes 25 mph. And the fastest EZGO gasoline golf cart also only goes 19 mph.

How fast can a 36V golf cart go?

Standard 36V and 48V golf carts are capable of the same top-end speed (12MPH). You can, however, make your golf cart go faster by doing a couple of things: Larger Tires - You can purchase larger tires.

Is 30 mph fast for a golf cart?

Depending on how far you want to go on a full charge, you might want a 40mph or a 30mph golf cart. At top speed, most golf carts do around 14mph. However, with the advent of street legal golf carts and modifications, it is possible to go 35mph and above.

How many miles will a 36 volt golf cart go?

A 36 volt golf cart is adequate for 2 to 4 passenger use when you are primarily using it on flat a flat surface. The average drive time or range for a 36 volt DC system is about 30 miles on a full charge.

How fast can a golf cart go without a governor?

Consider Replacing Your Speed Control

A typical electric cart without an upgraded speed control tops out around 12 mph. If you go this route, anticipate an upgrade cost around $700.

How do I unlock Freedom mode on EZ GO?

Toggle the forward/reverse switch from the "neutral" position to "reverse" five times in quick succession. After a few seconds, the computer controller will beep four times, indicating it has shifted into the freedom mode.

Can you make a Club Car go faster?

There are simple ways to increase the speed of your Club Car golf cart. Of course, there's always a hard way. For example, you could start by upgrading the controller, adding a heavy-duty forward reverse switch, then upgrade the existing motor, install a solenoid, battery, cables and—well, you get the idea.

How can I make my 2020 gas Club golf cart go faster?

Increase the RPM

An increase in the input shaft rpm for all differential ratios will produce a higher speed. For a gas golf cart, other than adjusting the governor, the speed may be enhanced by replacing the engine with a higher rpm output model.

Will bigger tires make my golf cart faster?

The larger surface area of the bigger tires and wheels increases the maximum possible miles per hour. In some cases, this can be a boost of 300%! The bigger the tires, the better the speed.

Why does my golf cart only run with the choke on?

Cart Runs Only When Choke is On

This is normally due to a blockage in the fuel line. Another cause is the accumulation of dirt or other debris in the carburetor. To fix this issue, check for any blockages in the fuel line and other engine components.

Why does my ezgo backfire?

The golf cart backfires through the carburetor because of an open throttle plate. The accelerator cable at the scale is out of adjustment and, in turn, stops the vessel from closing when the microswitch makes contact with the ignition.

Why do I have to choke my golf cart?

A golf cart choke is commonly used when starting a cold engine to restrict air flow while the fuel gets to the engine. Once the mixture stabilizes and the engine can run on its own without air restriction, the choke is released.

How do you make a gas golf cart faster?

6 Ways You Can Make a Golf Cart Faster

1. Add More Torque to Your Golf Cart.
2. Upgrade Your Golf Cart's Motor.
3. Improve the High-Speed Controller of the Cart.
4. Add Better Golf Cart Tires.
5. Use a Higher Powered Golf Cart Battery.
6. Watch the Weight in Your Golf Cart.

How do I test my EZ GO speed sensor?

Testing a Golf Cart Speed Sensor

1. Activate the Row/Tow switch. To do this, you must put the golf cart in the “run” position while pushing the cart itself. ...
2. Make sure the three-pin plug is connected to the sensor. To ensure it is connected, with the output of the green wire, place the piercing probe.

Should I charge my golf cart after each use?

Yes. New golf cart batteries should be charged every time they are used as this will extend their lifespan, help them retain their capacity for longer, and prevent discharge. It is vitally important to charge new golf cart batteries, even after their first use.